MicroPower
Direct
High Isolation, 2W Key Features
Ultra-Miniature SIP " 3,00 VDC Isolation "Ultra-Miniature SIP Package
DC/DC Converters " 2W Output Power " Single & Dual Outputs
D200I Series " -401C to +711C Operation " Low Cost
Electrical Specifications
Specifications typical @ +251C with nominal input voltage & rated output current, unless otherwise noted. Specifications subject to change without notice.
Input
Parameter Conditions Min. Typ. Max. Units
5 VDC Input 4.5 5.0 5.5
Input Voltage Range 12 VDC Input 10.8 12.0 13.2 VDC
24 VDC Input 21.6 24.0 26.4
Reverse Polarity Input Current 0.3 A
Input Filter Capacitor
Output
Parameter Conditions Min. Typ. Max. Units
Output Voltage Accuracy !5.0 %
Output Voltage Balance Dual Output , Balanced Loads !1.0 %
Line Regulation For Vin Change of 1% !1.0 %
Load Regulation Iout = 20% to 100% !8.0 %
Ripple & Noise (20 MHz) 150 mV P - P
Ripple & Noise (20 MHz) Over Line, Load & Temp. 150 mV P - P
Ripple & Noise (20 MHz) 5 mV rms
Output Power Protection 120 %
Temperature Coefficient !0.02 %/1C
Output Short Circuit Momentary (0.5 Sec.)
General
Parameter Conditions Min. Typ. Max. Units
Isolation Voltage 60 Seconds 3,000 VDC
Leakage Current 1.0 mA
Isolation Resistance 1,000 VDC 10 G
Isolation Capacitance 100 kHz, 1V 60 pF
Switching Frequency 85 kHz
Environmental
Parameter Conditions Min. Typ. Max. Units
Operating Temperature Range -40 +71 1C
Storage Temperature Range -55 +125 1C
Cooling Free Air Convection
Humidity RH, Non-condensing 90 %
Physical
Case Size 0.77 x 0.24 x 0.37 Inches (19.5 x 6.00 x 9.5 mm)
Case Material Non-Conductive Black Plastic
Weight 0.09 Oz (2.5g)
Reliability Specifications
Parameter Conditions Min. Typ. Max. Units
MTBF MIL HDBK 217F, 251C, Gnd Benign 3.6 MHours
Absolute Maximum Ratings
Parameter Conditions Min. Typ. Max. Units
5 VDC Input -0.7 9.0
Input Voltage Surge (1 Sec) 12 VDC Input -0.7 18.0 VDC
24 VDC Input -0.7 30.0
Internal Power Dissipation All Models 650 mW
Caution: Exceeding Absolute Maximum Ratings may damage the module. These are not continuous operating ratings.
MicroPower Direct
CompuMess Elektronik GmbH · Lise-Meitner-Str.1 · 85716 Unterschleissheim
" TEL: (781) 344-8226 " FAX: (781) 344-8481 " E-Mail: sales@micropowerdirect.com " WEB: www/micropowerdirect.com
Tel 089-321501-0 · Fax 089-321501-11 · www.compumess.de · www.netzteile.de
Model Selection Guide
Input Output Fuse Rating
Model Efficiency
Voltage (VDC) Current (mA) Voltage Current Current Slow-Blow
Number (%, Typ)
Nominal Range Full-Load No-Load (VDC) (mA, Max) (mA, Min) (mA)
D201I 5 4.5 - 5.5 452 60 3.3 500 10.0 73 1,000
D202I 5 4.5 - 5.5 555 28 5.0 400 8.0 72 1,000
D203I 5 4.5 - 5.5 500 28 12.0 167 3.0 80 1,000
D204I 5 4.5 - 5.5 494 26 15.0 134 2.5 81 1,000
D205I 5 4.5 - 5.5 555 28 !5.0 !200 !4.0 72 1,000
D206I 5 4.5 - 5.5 504 28 !12.0 !84 !1.5 79 1,000
D207I 5 4.5 - 5.5 494 25 !15.0 !67 !1.0 81 1,000
D211I 12 10.8 - 13.2 185 30 3.3 500 10.0 74 500
D212I 12 10.8 - 13.2 228 22 5.0 400 8.0 73 500
D213I 12 10.8 - 13.2 208 20 12.0 167 3.0 80 500
D214I 12 10.8 - 13.2 200 30 15.0 134 2.5 83 500
D215I 12 10.8 - 13.2 225 22 !5.0 !200 !4.0 74 500
D216I 12 10.8 - 13.2 208 20 !12.0 !84 !1.5 80 500
D217I 12 10.8 - 13.2 200 30 !15.0 !67 !1.0 82 500
D221I 24 21.6 - 26.4 92 15 3.3 500 10.0 74 200
D222I 24 21.6 - 26.4 109 10 5.0 400 8.0 76 200
D223I 24 21.6 - 26.4 102 9 12.0 167 3.0 82 200
D224I 24 21.6 - 26.4 102 8 15.0 134 2.5 82 200
D225I 24 21.6 - 26.4 111 11 !5.0 !200 !4.0 75 200
D226I 24 21.6 - 26.4 103 8 !12.0 !84 !1.5 81 200
D227I 24 21.6 - 26.4 102 8 !15.0 !67 !1.0 82 200
Derating Curve
100
80 Pin Connections
-3.0% / 1C
Output Power %
Pin Single Dual
60
1 +Vin +Vin
2 -Vin -Vin
40
5 -Vout -Vout
20
6 No Pin Common
7 +Vout +Vout
0
-40 -20 0 5 15 25 35 45 55 65 75 85 95 105
Ambient Temperature 1C
Mechanical Dimensions
Side
Capacitive Load 0.37
(9.5)
Single Output Dual Output
(µF Max) (µF Max)
470 !390 0.12
(3.0)
0.02 0.10
(0.5) (2.5)
0.08
0.60 (15.24)
(2.13)
Notes:
All dimensions are typical in inches (mm) 0.77 (19.5)
Tolerance x.xx = !0.01 (!0.25)
Pin 1 is marked by a "dot" or indentation on the side of the unit Bottom 0.30
(7.6)
1 2 5 6 7
0.01
0.01
(0.25) 0.05
(0.25)
(1.25)
MicroPower CompuMess Elektronik GmbH
232 Tosca Drive, Stoughton, MA 02072
Lise-Meitner-Str.1, 85716 Unterschleissheim
www.micropowerdirect.com
Direct Tel sales@micropowerdirect.com
089-321501-0 Fax 089-321501-11
phone: (781) 344 - 8226 * fax: (781) 344 - 8481
http://www.compumess.de oder http://www.netzteile.de