MicroPower
Direct
Miniature SIP, 2W Key Features
Regulated, Short Circuit Protected Miniature SIP Package 2.0W Output Power
DC/DC Converters Short Circuit Protected Tight Line/Load Regulation
D200RP Series 1.5 MH MTBF Low Cost
Electrical Specifications
Specifications typical @ +25ºC with nominal input voltage & rated output current, unless otherwise noted. Specifications subject to change without notice.
Input
Parameter Conditions Min. Typ. Max. Units
5 VDC Input 4.5 5.0 5.5
Input Voltage Range 12 VDC Input 10.8 12.0 13.2 VDC
24 VDC Input 21.6 24.0 26.4
Input Filter (Pi) Filter
Reverse Polarity Input Current 0.3 A
Output
Parameter Conditions Min. Typ. Max. Units
Output Voltage Accuracy ±2.0 %
Line Regulation For Vin Min to Max ±0.5 %
Load Regulation Iout = 20% to 100% ±0.5 %
Ripple & Noise (20 MHz) 75 mV P - P
Output Power Protection 120 %
Temperature Coefficient ±0.02 %/1C
Output Short Circuit Continuous
General
Parameter Conditions Min. Typ. Max. Units
Isolation Voltage 60 Seconds 1,000 VDC
Isolation Resistance 500 VDC 1,000 M
Isolation Capacitance 100 kHz, 1V 60 pF
Switching Frequency 40 kHz
Environmental
Parameter Conditions Min. Typ. Max. Units
Operating Temperature Range Ambient -40 +25 +85 ºC
Operating Temperature Range Case -40 +90 ºC
Storage Temperature Range -40 +125 ºC
Cooling Free Air Convection
Humidity RH, Non-condensing 95 %
Physical
Case Size (5V & 12V Models) 1.25 x 0.34 x 0.53 Inches (31.8 x 8.6 x 13.5 mm)
Case Material Non-Conductive Black Plastic
Weight (5V & 12V Input Models) 0.17 Oz (4.8g)
Reliability Specifications
Parameter Conditions Min. Typ. Max. Units
MTBF MIL HDBK 217F, 25ºC, Gnd Benign 1.5 MHours
Absolute Maximum Ratings
Parameter Conditions Min. Typ. Max. Units
5 VDC Input -0.7 9.0
Input Voltage Surge (1 Sec) 12 VDC Input -0.7 18.0 VDC
24 VDC Input -0.7 30.0
Lead Temperature 1.5 mm From Case For 10 Sec 260 ºC
Internal Power Dissipation All Models 450 mW
Caution: Exceeding Absolute Maximum Ratings may damage the module. These are not continuous operating ratings.
CompuMess Elektronik GmbH · Lise-Meitner-Str.1 · 85716 Unterschleissheim
Tel 089-321501-0 · Fax 089-321501-11 · www.compumess.de · www.netzteile.de
Model Selection Guide
Input Output Fuse Rating
Model Efficiency
Voltage (VDC) Current (mA) Voltage Current Current Slow-Blow
Number (%, Typ)
Nominal Range Full-Load No-Load (VDC) (mA, Max) (mA, Min) (mA)
D201RP 5 4.5 - 5.5 606 60 5.0 400.0 40.0 66 1,000
D202RP 5 4.5 - 5.5 606 60 9.0 222.0 22.0 66 1,000
D203RP 5 4.5 - 5.5 571 60 12.0 167.0 17.0 70 1,000
D204RP 5 4.5 - 5.5 571 60 15.0 133.0 13.0 70 1,000
D205RP 5 4.5 - 5.5 588 60 24.0 83.0 10.0 68 1,000
D211RP 12 10.8 - 13.2 253 30 5.0 400.0 40.0 66 500
D212RP 12 10.8 - 13.2 253 30 9.0 222.0 22.0 66 500
D213RP 12 10.8 - 13.2 238 30 12.0 167.0 17.0 70 500
D214RP 12 10.8 - 13.2 238 30 15.0 133.0 13.0 70 500
D215RP 12 10.8 - 13.2 246 30 24.0 83.0 10.0 68 500
D221RP 24 21.6 - 26.4 130 15 5.0 400.0 40.0 64 200
D222RP 24 21.6 - 26.4 130 15 9.0 222.0 22.0 64 200
D223RP 24 21.6 - 26.4 122 15 12.0 167.0 17.0 68 200
D224RP 24 21.6 - 26.4 122 15 15.0 133.0 13.0 68 200
D225RP 24 21.6 - 26.4 118 15 24.0 83.0 10.0 70 200
Notes: Derating Curve
1. These units do not require external como- 100
nents to operate, but the use of an input
capacitor (10 µF) may enhance perfor-
mance in some applications. An output 80
capacitor (4.7 µF to 10 µF) may be used to
Output Power %
reduce ripple.
60
-5.0%/ 1C
40
Capacitive Load
µF Max 20
470
0
-40 -10 0 5 15 25 35 45 55 65 75 85 95 105
Ambient Temperature 1C
Pin Connections Mechanical Dimensions
Pin Single
1 +Vin
2 NC
5.3
3 NC Side (13.47)
9 NC
0.02
10 -Vout (0.50)
11 +Vout
12 -Vin
NC: No Connection
0.10 0.08
0.60 (15.24) (2.5) (2.13)
1.25 (31.80)
0.02 0.02
(0.50) (0.50)
Notes: All dimensions are typical in inches 0.01
(mm) (0.25)
Tolerance x.xx = ±0.01 (±0.25) 0.34
Pin 1 is marked by a "dot" or indentation
Bottom (8.64)
on the side of the unit 1 2 3 9 10 11 12 0.15
(3.81)
MicroPower CompuMess Elektronik GmbH
Lise-Meitner-Str.1, 85716 Unterschleissheim
Direct Tel 089-321501-0 Fax 089-321501-11
http://www.compumess.de oder http://www.netzteile.de